Labour
$149/hr
Service Calls
$125
Pick Up & Delivery
$125 ROUND TRIP
What's included in a Service Call & Equipment Maintenance
Keep your equipment ready for the season with comprehensive inspections, maintenance and servicing. Explore what’s included for each type of equipment below, from harvesters and wind machines to tractors, sprayers and icewine presses.
Harvester Service / Maintenance
Service is recommended within the first 50 hours (Inclusive with purchase of a new machine from LVE), then every 200 hours. Pre-Season Inspection and Post-Season Inspection Available. Picking Head to Sprayer or Sprayer to Picking Head Swap also available. 24/7 Emergency service available.
-
Engine
- Replace engine oil and filter as required
- Replace hydraulic oil and filter as required
- Replace fuel filter and air filters as required
- Check belt tension and inspect fans
- Check battery terminals, test starting and charging systems
- Check wiring for corrosion and / or rodent damage
- Check all switches and gauges for proper operation
- Check coolant and refrigerant
-
Picking Head
- Inspect all belts for tension and wear
- Check all pulleys and bearings
- Inspect all rods and rod holders
- Check bin chains and cross conveyor
- Inspect catching trays
- Inspect for / make necessary adjustments
- Full clean
-
Cab
- Test all lights and sensors
- Test all interior controls ie. Radio, A/C, ect.
- Test joystick functions
- Clean
Price May Vary Based on Parts & Labour
Price May Vary Based on Parts & Labour.
Wind Machine Service
Wind Machine Service is available on a first come first service basis. Service is preferably booked between May 1st and July 31st. 24/7 Emergency service available during a frost.
-
Engine
- Replace engine oil and filter, fuel and air filters (as required)
- Tighten all belts, pulleys, and hoses, check water pump and radiator for leaks
- Check all wiring for corrosion and / or rodent damage. Repair as required
- Check all switches and gauges for proper operation
- Service battery, clean terminals, test starting and charging systems
Full Service $549 + Parts & Additional Labour
-
Tower
- Check oil level and condition in upper and lower gearboxes.
- Check for oil leak at input and output shafts
- Visually inspect blade for damage and/or worn bushings
- Check drive shaft U-joints, support bearings and shear coupler
- Check clutch operation
- Replace lower gearbox filter (If equipped)
Full Service $549 + Parts & Additional Labour.
Tractor & Equipment Service
See what's included:
-
What We Check & Fix
- Check all functions of unit interior and exterior
- Remove and replace filters and fluids as needed
- Hoses & Clamp check
- Antifreeze check
- Full grease for unit
- Check battery terminals, test starting and charging systems
- Full exterior clean/detailing
- Check tires, rims, hubs and axles
May Vary Based on Parts & Labour. Dyno Horse Power Testing Available.
Sprayers & Vineyard Equipment
End-of-Season Inspection with Winterizing Available.
-
What We Check & Fix
- Remove all covers
- Inspect gearbox shaft for alignment/wear
- Replace gearbox oil (Upper and lower if applicable)
- Replace pump oil
- Inspect & Grease all u-joints
- Inspect belts
- Inspect & clean filter
- Fill unit with water – Test run all functions
- Test all switches and gauges for proper operation
- Inspect nozzle operation
- Inspect for leaks
- Check oil levels
- Grease Unit
- Check tires for pressure and wear
- Wash Unit
Price May Vary Based on Parts & Labour.
Icewine Press Service
Service call included.
-
What We Check & Fix
- Check hydraulic lines and fittings for leaks
- Check seals on hydraulic ram
- Lift motors visually inspect pump and pump bearings
- Verify pressure gauge shut off function
- Check condition of hydraulic oil
- Verify oil heater function
- Visually inspect all electronics
- Verify pumps build pressure and adjust where possible, inspect and clean oil intake filter(replace if req'd)
- Parts and additional labour extra
$148.00 + Parts & Labour.